首页 | 期刊介绍 | 编委会 | 道德声明 | 投稿指南 | 常用下载 | 过刊浏览 | In English
引用本文:吴培凤,周德庆,孙 永,李月欣,牟伟丽,刘 楠.响应面法优化浒苔半纤维素的提取条件及其组分分析[J].海洋科学,2017,41(1):48-56.
【打印本页】   【HTML】   【下载PDF全文】   查看/发表评论  下载PDF阅读器  关闭
←前一篇|后一篇→ 过刊浏览    高级检索
本文已被:浏览 1433次   下载 1328 本文二维码信息
码上扫一扫!
分享到: 微信 更多
响应面法优化浒苔半纤维素的提取条件及其组分分析
吴培凤1,2, 周德庆1, 孙 永1, 李月欣1,2, 牟伟丽3, 刘 楠1
1.中国水产科学研究院 黄海水产研究所;2.上海海洋大学 食品学院;3.山东汇洋集团
摘要:
以浒苔(Enteromorpha prolifera)为原料, 采用响应面法优化碱性过氧化氢提取半纤维素的条件。在单因素实验的基础上, 运用Box-Benhnken中心组合原理, 设计四因素三水平实验, 确定半纤维素最佳提取条件。采用红外光谱(FT-IR)和离子色谱(IC)分析浒苔半纤维素组分。结果表明, 各因素对浒苔半纤维的提取率的影响为: 时间>温度>料液比>氢氧化钠浓度。碱性过氧化氢法提取半纤维素的最佳条件为: 氢氧化钠浓度为4.8 g/L, 提取温度为92℃, 提取时间为5 h, 料液比1︰ 70, 半纤维素的提取率为56.75%, 与预测值57.30%基本一致。FT-IR结果显示, 浒苔半纤维素红外吸收光谱中含有明显的木糖和阿拉伯糖的特征吸收峰, 为吡喃环结构, 由β-糖苷键连接。离子色谱结果表明, 浒苔半纤维素主要由木糖和阿拉伯糖组成, 含有少量葡萄糖和半乳糖。木糖含量为54.4%, 其次为阿拉伯糖, 含量为15.3%, 葡萄糖和半乳糖含量分别为5.6%和2.7%。
关键词:  浒苔(Enteromorpha prolifera)  半纤维素  分离纯化  组分分析  响应面法
DOI:10.11759/hykx20160130001
分类号:
基金项目:中央级公益性科研院所基本科研业务费(20603022015001);烟台市高端人才引进‘双百计划’(XY-04-18-01)青岛市市南区科技发展资金项目(2014-14-008-SW)
Optimization of hemicellulose extractionfrom Enteromorpha prolifera using response surface method and component analysis
WU Pei-feng,ZHOU De-qing,SUN Yong,LI Yue-xin,MU Wei-li,LIU Nan
Abstract:
We optimized alkaline hydrogen peroxide extraction conditions of HC in Ep by RSM using Box–Behnken central composite principle to design experiments with four factors and three levels. HC components were analyzed using FT-IR and IC. The results showed that the following factors influence the extraction amount of HC in that order: time> temperature > ratio of Ep to solvent > concentration of sodium hydroxide. The optimal extraction conditions included a solid to liquid ratio of 1︰70, sodium hydroxide concentration of 4.8g/L, temperature of 92℃), and extraction time of 5h. The extraction rate was observed to be 56.75%, consistent with the predicated value of 57.30%. FT-IR results showed that HC contains xylose and arabinose absorption peaks and pyran ring structure connected by beta-glycosidic bond. IC results showed that HC was mainly comprised xylose (54.4%), arabinose (15.3%), glucose (5.6%), and galactose (2.7%).
Key words:  Enteromorpha prolifera  Hemicellulose  Separation and purification  Component analysis  Response surface methodology
版权所有 《海洋科学》 Copyright©2008 All Rights Reserved
主管单位:中国科学院 主办单位:中国科学院海洋研究所
地址:青岛市市南区福山路32号  邮编:266071  电话:0532-82898755  E-mail:marinesciences@qdio.ac.cn
技术支持:北京勤云科技发展有限公司